Product ID:POLYURETHANE AEROSOL COLORS
MSDS Date:01/01/1995
FSC:8010
NIIN:01-378-0188
Status Code:A
MSDS Number: CLBWC

PACIFIC WEST CHEMICAL CORP

337 SUMMIT DR
CORTE MADERA, CA 94925-0183
US

Emergency Phone: 415-924-4425

Info Phone: 415-924-4560

Preparer: ERNEST CARTER

Cage: 58977

PACIFIC WEST CHEMICAL CORP

183 CORTE MADERA, CA 94925-0183 US

Telephone: 415-924-4560

Cage: 58977

ACETONE

CAS: 67-64-1

RTECS: AL3150000

OSHA PEL 2400 MG/M3;1000 PPM

ACGIH TLV: 1780 MG/M3;750 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

N-BUTYL ACETATE

CAS: 123-86-4

RTECS: AF7350000

OSHA PEL 710 MG/M3;150 PPM

ACGIH TLV: 713 MG/M3;150 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

XYLENE

CAS: 1330-20-7

RTECS: ZE2100000

ACGIH TLV: 434 MG/M3;100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

NAPHTHA, SOLVENT

CAS: 8052-41-3

RTECS: WJ8925000

OSHA PEL 2900 MG/M3;500 PPM

ACGIH TLV: 525 MG/M3;100 PPM

PROPANE

CAS: 74-98-6

RTECS: TX2275000

Fraction By Weight: 15%

OSHA PEL 1800 MG/M3;1000 PPM

ISOBUTANE

CAS: 75-28-5

RTECS: TI4300000

BUTANE

CAS: 106-97-8

RTECS: EJ4200000

ACGIH TLV: 1900 MG/M3;800 PPM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:INHALATION: ANESTHETIC. IRRITATION OF
THE RESPIRATORY TRACT, OR NERVOUS SYSTEM, DEPRESSION CHARACTERIZED
BY HEADACHE, DIZZINESS, NAUSEA, OR POSSIBLE UNCONSCIOUSNESS.SKIN OR
EYE CONTACT: PRIMARY IRRITA TION. PROLONGED OR REPEATED CONTACT TO
SKIN MAY CAUSE DERMATITIS-EXERCISE DUE CARE.

First Aid:VAPORS: REMOVE FROM EXPOSURE AND RESTORE BREATHING, SEEK
MEDICAL ATTENTION. SPLASH:[SKIN] WASH AFFECTED AREA, REMOVE
CONTAMINATED CLOTHING, SEE PHYSICIAN IF ANY IRRITATION PERSISTS.
SPLASH [EYES] FLUS H IMMEDIATELY WITH WATER FOR 15 MINUTES AND TAKE
TO A PHYSICIAN.

Flash Point Method:TCC
Flash Point:=-26.C, -14.8F
Lower Limits:0.7%
Upper Limits:12.8%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE, BUT WATER
SPRAY MAY BE USED TO COOL CONTAINERS EXPOSED TO HEAT OR FIRE TO
PREVENT PRESSURE BUILD UP.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE DUE TO
BUILD UP OF PRESSURE FROM EXTREME HEAT OR FIRE. AEROSOL SPRAY IS
EXTREMELY

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION: FLAMES,
SPARKS, STATIC ELETRICITY AND ELECTRICAL. VENTILATE AREA AND SOAK
UP WITH INERT ABSORBENT USING NON-SPARKING TYPE TOOLS.

Handling and Storage Precautions:DO NOT STORE ABOVE 120 DEG.F. DO NOT
STORE OR USE NEAR HEAT, SPARKS, OR FLAME.
Other Precautions:DO NOT GET IN EYES. DO NOT BREATHE VAPORS. AVOID SKIN
CONTACT. DO NOT TAKE INTERNALLY. SMOKING WHILE USING THIS PRODUCT
MUST BE STRICTLY PROHIBITED. IN ADDITION TO ALL OTHER HAZARDS AND
PRECAUTIONS-DU ST FROM SANDING THE DRY PAINT FILMS SHOULD BE
TREATED AS A NUISANCE DUST WITH A TLV OF 10MG/CUBIC ME TER.

Respiratory Protection:OUTDOORS: WE RECOMMEND AN APPROVED PARTICULATE
FILTER TO REMOVE ANY AIRBORNE OVERSPRAY IN RESTRICTED AREAS WITH
POOR VENTILATION AND CLOSE TO THE T.L.V. INDOORS: A NIOSH APPROVED
RESPIRATOR WITH ORGAN IC VAPOR CARTRIDGE IS RECOMMENDED.
Ventilation:ALL APPLICATION AREAS SHOULD BE ADEQUATELY VENTILATED IN
ORDER TO KEEP THE INGREDIENTS IN SECTIONII BELOW THEIR
EXPOSURELIMITS.
Protective Gloves:IMPERVIOUS GLOVES ARE RECOMMENDED TO PREVENT SKIN
CONTACT.
Eye Protection:SAFTY GLASSES WITH SIDE SHIELDS IS RECOMMENDED TO
PREVENT EYE CONTACT.
Other Protective Equipment:EYE WASH FOUNTAIN AND SAFTY SHOWER.
IMPERVIOUS APRON TO PREVENT SKIN CONTACT IS RECOMMENDED.
Work Hygienic Practices:AVOID PROLONGED OR REPEATED CONTACT. DO NOT
BREATHE VAPORS. WASH CONTAMINATED CLOTHING PRIOR TO RE-USE.
Supplemental Safety and Health

Boiling Pt:=-23.3C, -10.F
Vapor Density:>AIR
Spec Gravity:0.7
VOC Pounds/Gallon:607
Evaporation Rate & Reference:> BUTYL ACETATE
Appearance and Odor:OPAQUE LIQUID/SOLVENT BASE ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:CO,CO2, HCL, AND POSSIBLY TRACES OF
PHOSGENE.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATION. DO NOT INCINERATE CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.